武汉盛美特机电设备有限公司主营：REXROTH德国力士乐、VICKERS美国威格士、ATOS意大利阿托斯、

SUN美国太阳、DEN***N法国丹尼逊、PARKER美国派克、DUPLOMATIC意大利迪普马、HAWE德国哈威、

HYDAC贺德克，CALZONI意大利卡桑尼、MOOG美国穆格,HYDRAFORCE海德福斯,雅歌辉托斯等,价格优势，欢迎询价。

简介

变量柱塞泵的压力油经泵体、泵壳变量壳体中的通油孔通过单向阀进入变量壳体的下腔，当拉杆向下运动时，推动伺服活塞向下移动，伺服阀的上阀口打开，变量壳体下腔的压力油经变量活塞中的通油孔进入变量壳体上腔，由于上腔面积大于下腔，液压力推动活塞向下运动，带动销轴使变量头绕钢球中心旋转，改变变量头的倾斜角（增大），柱塞泵的流量随之增大。反之拉杆向上运动，变量头的倾斜角向相反方向变化，泵的流量也随之变化。当倾斜角度变至零以后，则变量头向负偏角方向变化，液流产生换向，泵的进出油口变换 [1]  。

常见故障

1.液压泵输出流量不足或不输出油液

(1)吸入量不足。原因是吸油管路上的阻力过大或补油量不足。

如泵的转速过大，油箱中液面过低，进油管漏气，滤油器堵塞等。

(2)泄漏量过大。原因是泵的间隙过大，密封不良造成。如配油盘被金属碎片、铁屑等划伤，端面漏油；变量机构中的单向阀密封面配合不好，泵体和配油盘的支承面有砂眼或研痕等。可以通过检查泵体内液压油中混杂的异物判别泵被损坏的部位。

(3)倾斜盘倾角太小，泵的排量少，这需要调节变量活塞，增加斜盘倾角。

2.中位时排油量不为零

变量式轴向柱塞泵的斜盘倾角为零时称为中位，此时泵的输出流量应为零。但有时会出现中位偏离调整机构中点的现象，在中点时仍有流量输出。其原因是控制器的位置偏离、松动或损伤，需要重新调零、紧固或更换。泵的角度维持力不够、倾斜角耳轴磨损也会产生这种现象。

3.输出流量波动

输出流量波动与很多因素有关。对变量泵可以认为是变量机构的控制不佳造成，如异物进入变量机构，在控制活塞上划出阶痕、磨痕、伤痕等，造成控制活塞运动不稳定。由于放大器能量不足或零件损坏、含有弹簧的控制活塞的阻尼器效能差，都会造成控制活塞运动不稳定。流量不稳定又往往伴随着压力波动。这类故障一般要拆开液压泵，更换受损零部件，加大阻尼，提高弹簧刚度和控制压力等。

4.输出压力异常

泵的输出压力是由负载决定的，与输入转矩近似成正比。输出压力异常有两种故障。

(1)输出压力过低

当泵在自吸状态下，若进油管路漏气或系统中液压缸、单向阀、换向阀等有较大的泄漏，均会使压力升不上去。这需要找出漏气处，紧固、更换密封件，即可提高压力。溢流阀有故障或调整压力低，系统压力也上不去，应重新调整压力或检修溢流阀。如果液压泵的缸体与配流盘产生偏差造成大量泄漏，严重时，缸体可能破裂，则应重新研磨配合面或更换液压泵。

(2)输出压力过高

若回路负载持续上升，泵的压力也持续上升，当属正常。若负载一定，泵的压力超过负载所需压力值，则应检查泵以外的液压元件，如方向阀、压力阀、传动装置和回油管道。若压力过高，应调整溢流阀。

5.振动和噪声

振动和噪声是同时出现的。它们不仅对机器的操作者造成危害，也对环境造成污染。

(1)机械振动和噪声

如泵轴和电机轴不同心或顶死，旋转轴的轴承、联轴节损伤，弹性垫破损和装配螺栓松动均会产生噪声。对于高速运转或传输大能量的泵，要定期检查，记录各部件的振幅、频率和噪声。如泵的转动频率与压力阀的固有频率相同时，将会引起共振，可改变泵的转速以消除共振。

(2)管道内液流产生的噪声

进油管道太细、进油滤油器通流能力过小或堵塞、进油管吸入空气、油液豁度过高、油面过低吸油不足和高压管道中产生液击等，均会产生噪声。因此，必须正确设计油箱，正确选择滤油器、油管和方向阀。

6.液压泵过热

液压泵过度发热有两个原因，一是机械摩擦生热。由于运动表面处于干摩擦或半干摩擦状态，运动部件相互摩擦生热。二是液体摩擦生热。高压油通过各种缝隙泄漏到低压腔，大量的液压能损失转为热能。所以正确选择运动部件之间的间隙、油箱容积和冷却器，可以***泵的过度发热和油温过高的现象。另外，回油过滤器堵塞造成回油背压过高，也会引起油温过高和泵体过热。

A10VSO系列 液压变量柱塞泵 

936130 A10VSO28DFLR/31R-PPA12N00 

936062 A10VSO28DFLR/31R-PPA12N00 

936059 A10VSO28DFLR/31R-PPA12N00 

940936 A10VSO28DFLR/31R-PPA12N00 力士乐Rexroth

939026 A10VSO28DFLR/31R-PPA12N00 

903160 A10VSO28DFR/31R-PPA12N00 

926318 A10VSO28DFR1/31R-PPA12K01 

910590 A10VSO28DFR1/31R-PPA12N00 力士乐Rexroth

907919 A10VSO28DR/31R-PPA12K01 

903163 A10VSO28DR/31R-PPA12N00 

936910 A10VSO45DFLR/31R-PPA12N00 

936912 A10VSO45DFLR/31R-PPA12N00 力士乐Rexroth

936739 A10VSO45DFLR/31R-PPA12N00 

935975 A10VSO45DFLR/31R-PPA12N00 

940582 A10VSO45DFLR/31R-PPA12N00 

909613 A10VSO45DFR/31R-PPA12K01 力士乐Rexroth

911010 A10VSO45DFR/31R-PPA12K26 

939183 A10VSO45DFR/31R-PPA12N00 

927068 A10VSO45DFR1/31R-PPA12K02 

908725 A10VSO45DFR1/31R-PPA12N00 力士乐Rexroth

907403 A10VSO45DR/31R-PPA12N00 

944067 A10VSO71DFLR/31R-PPA12N00 

944730 A10VSO71DFLR/31R-PPA12N00 

942654 A10VSO71DFLR/31R-PPA12N00 力士乐Rexroth

944502 A10VSO71DFLR/31R-PPA12N00 

948790 A10VSO71DFLR/31R-PPA12N00 

961216 A10VSO71DFLR/31R-PPA12N00 

944440 A10VSO71DFR1/31R-PPA12N00 力士乐Rexroth

945133 A10VSO71DR/31R-PPA12N00 

936207 A10VSO100DFLR/31R-PPA12N00 

936738 A10VSO100DFLR/31R-PPA12N00 

936473 A10VSO100DFLR/31R-PPA12N00 力士乐Rexroth

936790 A10VSO100DFLR/31R-PPA12N00 

934823 A10VSO100DFLR/31R-PPA12N00 

944032 A10VSO100DFLR/31R-PPA12N00 

943468 A10VSO100DFLR/31R-PPA12N00 力士乐Rexroth

939643 A10VSO100DFR/31R-PPA12N00 

927083 A10VSO100DFR1/31R-PPA12K02 

922744 A10VSO100DFR1/31R-PPA12N00 

912007 A10VSO100DR/31R-PPA12N00 力士乐Rexroth

936094 A10VSO140DFLR/31R-PPB12N00 

935974 A10VSO140DFLR/31R-PPB12N00 

941109 A10VSO140DFLR/31R-PPB12N00 

938977 A10VSO140DFLR/31R-PPB12N00 力士乐Rexroth

943841 A10VSO140DFLR/31R-PPB12N00 

939192 A10VSO140DFR/31R-PPB12N00 

927126 A10VSO140DFR1/31R-PPB12K02 

921546 A10VSO140DFR1/31R-PPB12N00 力士乐Rexroth

922983 A10VSO140DR/31R-PPB12N00 

932852 A10VSO140DRG/31R-PPB12N00 

945179 A10VSO71DFR/31R-PPA12K27 

942635 A10VSO71DFR/31R-PPA12N00 力士乐Rexroth

947872 A10VSO71DFR1/31R-PPA12K02 

948654 A10VSO71DFLR/31R-PPA12N00

优惠供应: 德国力士乐Rexroth泵、阀、马达全系列，意大利阿托斯ATOS液压，美国伊顿EATON威格士

VICKERS泵、阀，美国派克PARKER泵、阀等等。

PVV2-1X/040RA15DMB  PVV2-1X/045RA15DMB力士乐Rexroth

PVV2-1X/055RA15DMB  PVV2-1X/060RA15DMB

PVV2-1X/068RA15DMB  PVV4-1X/069RA15DMB

PVV4-1X/082RA15DMB  PVV4-1X/098RA15DMB力士乐Rexroth

PVV4-1X/113RA15DMB  PVV4-1X/122RA15DMB

PVV5-1X/139RA15DMB  PVV5-1X/154RA15DMB

PVV5-1X/162RA15DMB  PVV5-1X/183RA15DMB力士乐Rexroth

PVV5-1X/193RA15DMB

PVV21-1X/060-040RA15DDMB，PVV21-1X/068-027RA15LUMB力士乐Rexroth

PVV41-1X/098-027RA15UDMC，PVV41-1X/122-036RA15DDMC

PVV42-1X/098-045RA15DDMC，PVV21-1X/068-027RA15LUMB

PVV51-1X/162-036RB15DDMC，PVV51-1X/193-027RA15DDMC力士乐Rexroth

PVV52-1X/193-040RB15URMC，PVV52-1X/193-055RB15UUMC

PVV54-1X/183-082RA15DDMC， PVV54-1X/139-082RA15UUMC

PVQ2-1X055RA15DLMB，PVQ2-1X068RA15DLMB力士乐Rexroth

PVQ21-1X060-018RA15DLMB，PVQ4-1X/82RA-15DMC

PVQ4-1X/98RA-15DMC，PVQ4-1X/113RA-15DMC

PVQ4-1X/122RA-15DMC，PVQ5-1X/139/154/162/193力士乐Rexroth

PVQ21-1X/060-040RA15DDMB，PVQ21-1X/068-027RA15LUMB

PVQ41-1X/098-027RA15UDMC，PVQ41-1X/122-036RA15DDMC

PVQ42-1X/098-045RA15DDMC，PVQ21-1X/068-027RA15LUMB力士乐Rexroth

PVQ51-1X/162-036RB15DDMC，PVQ51-1X/193-027RA15DDMC

PVQ52-1X/193-040RB15URMC，PVQ52-1X/193-055RB15UUMC

PVQ54-1X/183-082RA15DDMC  PVQ54-1X/139-082RA15UUMC

R901116694 PVV52-1X/139-068RA15DLMC

R901106500 PVV5-1X/193RA15LMC

R900618320 PVV54-1X/139-069RA15UUMC

R900617458 PVV2-1X/068RJ15UMB

R900616927 PVV4-1X/113RJ15UMC

R961002468 WELLE PVV/PVQ54-1X/J+LAGER

R961002460 WELLE PVV/PVQ51-1X/J+LAGER

R961002459 WELLE PVV/PVQ51-1X/B+LAGER

R961002443 WELLE PVV/PVQ 5-1X/B+LAGER

R961002441 WELLE PVV/PVQ 5-1X/A+LAGER

R961002440 WELLE PVV/PVQ 4-1X/J+LAGER

R901141365 PVV1-1X/027LA15LMB

R901138307 PVV42-1X/082-045RA15DDMC

R901127013 PVV1-1X/027RJ15DVB

R901125797 PVV54-1X/162-082RB15UUMC

R901123353 PVV41-1X/082-018RA15RRVC

R901120947 PVV41-1X/082-046RA15UUMC

R901116697 PVV51-1X/139-027RA15DLMC

R901116694 PVV52-1X/139-068RA15DLMC

R901110909 PVV21-1X/040-018RB15UDMB

R901108431 PVV5-1X/154RJ15DVC

R901107242 PVV21-1X/055-018RA15UUVB

R901106500 PVV5-1X/193RA15LMC

R901104702 PVV4-1X/122RA15RMC

R901104691 PVV54-1X/154-113RJ15UUMC

R901100678 PVV21-1X/045-027RJ15UUMB

R901100223 ABUPG-PVV4- 98U-1X/132M-4-B1K/SE SIE

R901100169 PVV21-1X/068-027RA15URMB

R901099056 PVV51-1X/154-027RA15RRVC

R901098483 PVV54-1X/193-122RA15UUVC

R901094926 PVV54-1X/193-113RA15UUVC

R901094615 ABUPG-PVV1- 46U-1X/100L-4-AG0/SE

R901093768 PVV1-1X/046RA15DVB

R901092271 PVV41-1X/082-036RA15LLMC

R901091909 PVV2-1X/060RA15LMB

R901091196 PVV54-1X/193-082RA15DDMC

R901089304 SY2DFEE-2X/045-PVV/01089270+00940260

R901089061 PVV52-1X/154-055RA15UUMC

R901086511 PVV42-1X/082-068RA15UUMC

R901085408 PVV54-1X/183-122RB15DDMC

R901085403 PVV54-1X/139-098RB15DDMC

R901085400 PVV52-1X/162-055RB15DDMC

R901085398 PVV52-1X/154-068RB15DDMC

R901085395 PVV51-1X/154-046RB15DDMC

R901085392 PVV51-1X/139-027RB15DDMC

R901085390 PVV42-1X/082-045RB15DDMC

R901085387 PVV42-1X/098-040RB15DDMC

R901085385 PVV41-1X/113-018RB15DDMC

R901085383 PVV41-1X/122-027RB15DDMC

R901085381 PVV21-1X/068-018RB15DDMB

R901085379 PVV21-1X/055-027RB15DDMB

R901084887 PVV52-1X/193-045RA15DDMC

R901083429 PVV54-1X/139-113LB15DDMC

R901081361 PVV21-1X/055-018RA15DDMB

R901080702 PVV5-1X/193RA15DVC

R901080473 PVV52-1X/193-068LA15UUMC

R901079432 PVV1-1X/027RA15RMB

R901078751 PVV51-1X/139-018RJ15DLMC

R901077322 PVV51-1X/193-027RB15UUMC

R901076988 PVV5-1X/162LA15DMC

R901075202 PVV42-1X/113-055RA15UUMC

R901075200 PVV41-1X/122-046RA15UUMC

R901074802 PVV21-1X/060-018RB15DDMB

R901069521 PVV51-1X/139-027RB15LLMC

R901066306 PVV21-1X/040-018RA15RRMB

R901063719 PVV42-1X/098-068RB15UUMC

R901063622 PVV2-1X/055RA15LMB

R901062107 ABHPG-PVV1-018U/90L-6-W1/SF

R901059672 PVV54-1X/162-122RA15DDMC

R901061186 PVV51-1X/193-018RA15LDMC

R901057121 PVV51-1X/193-046RA15DDMC

R901055602 PVV4-1X/113LA15UMC

R901054757 ABHPG-PVV1-027D/90L-4-A1/SBF

R901053049 PVV51-1X/193-046RA15DLMC

R901053014 PVV51-1X/193-046LA15DLMC

R901050795 PVV54-1X/183-069RA15UUMC

R901045673 PVV4-1X/098RA15LMC

R901044270 PVV2-1X/040RA15UVB

R901042655 PVV54-1X/154-082RA15UUMC

R901042651 PVV41-1X/082-040RA15UUMC

R901042169 PVV21-1X/045-040LA15UUMB

R901040968 PVV1-1X/040RA15UVB

R901040503 PVV1-1X/036RJ15DVB

R901040430 ABUPG-PVV1- 46U-1X/100L-4-A0K/S ABB

R901037970 PVV1-1X/018RA15RMB

R901036232 PVV51-1X/193-027RA15UUMC

R901034701 PVV54-1X/193-122RJ15DDMC

R901033123 ABUPG-PVV21- 45- 18U-1X/100L-4-A0/S

R901031937 PVV2-1X/055RA15DVB

R901031658 PVV21-1X/068-046RA15UUMB

R901029208 ABAPG-PVV2-068U/100L-4-A0/SE

R901028783 PVV2-1X/045LA15UMB

R901027161 ZUBEHOER AB41-20A1X/B35-100/0-PVV2/M

R901026966 PVV54-1X/154-122RB15UUMC

R901025366 ABUPG-PVV1- 18U-1X/ 80 -4-O1HAN10ESS/S

R901024714 PVV51-1X/162-046RA15DDMC

R901024704 PVV4-1X/082RJ15UMC

R901023158 PVV21-1X/045-040RA15UUMB

R901020330 PVV41-1X/122-027RA15DDMC

R901020329 PVV52-1X/193-045RB15LLMC

R901018208 PVV54-1X/139-122RJ15UUMC

R901014437 PVV4-1X/082LA15UMC

R901012238 PVV4-1X/122RA15DVC

R901012150 PVV41-1X/082-018RB15UUMC

R901009013 PVV21-1X/040-027RA15UUMB

R901006812 SY2DFEE-2X/100-PVV/01006744+00940446

R901006811 SY2DFEE-2X/071-PVV/01006745+00946959

R901004734 PVV21-1X/055-036RA15UUMB

R901002834 PVV41-1X/069-018RJ15UUMC

R901002823 PVV52-1X/162-068RA15UUMC

R901001457 SY2DFEE-2X/071-PVV/00782146+00940260

R900978703 PVV4-1X/082RA15DVC

R900977523 ABAPG-PVV /017D493A

R900977417 PVV5-1X/162RA15RMC

R900976172 PVV41-1X/098-018RA15UUMC

R900976001 PVV54-1X/162-082RA15DDMC

R900973408 PVV1-1X/027RA15UVB

R900972481 PVV42-1X/122-055RA15UUMC

R900970917 PVV5-1X/162RB15DVC

R900970135 PVV1-1X/036LA15UMB

R900969172 PVV21-1X/045-018RB15URMB

R900969090 PVV21-1X/040-018LA15URVB

R900968783 PVV21-1X/045-027RA15UUMB

R900968642 PVV2-1X/055RA15UVB

R900968079 PVV21-1X/045-040RA15UDMB

R900968078 PVV1-1X/040LA15UMB

R900968076 PVV2-1X/060LA15UMB

R900966979 PVV41-1X/069-018RA15DDMC

R900965263 PVV42-1X/122-040RA15UUMC

R900962361 PVV54-1X/193-122RA15UUMC

R900961088 PVV54-1X/193-122RB15DDMC

R900957021 PVV21-1X/055-046RA15UUMB

R900954326 PVV5-1X/139RA15UMC

R900952889 PVV21-1X/055-027RA15UUMB

R900950523 PVV21-1X/060-036RA15DDMB

R900949682 PVV5-1X/183LA15DMC

R900949681 PVV5-1X/193LA15DMC

R900949676 PVV51-1X/183-046RA15DDMC

R900949510 PVV54-1X/139-082RB15DDMC

R900949069 PVV2-1X/060RA15RMB

R900948951 PVV21-1X/068-040RA15DDMB

R900948873 PVV51-1X/139-046LB15UUMC

R900948168 PVV21-1X/045-027RA15DDMB

R900947492 PVV2-1X/045RA15UVB

R900947385 PVV5-1X/139RA15RVC

R900946959 PVV2-1X/040RJ15UMB

R900946296 PVV5-1X/139RA15DVC

R900945850 PVV4-1X/082RJ15DMC

R900945761 PVV4-1X/122RA15LMC

R900945544 PVV5-1X/193LB15DMC

R900945381 PVV21-1X/040-036RB15DUMB

R900945229 PVV54-1X/193-098RB15DDMC

R900945128 PVV1-1X/018RJ15UMB

R900945121 PVV54-1X/183-098RB15DUMC

R900944546 PVV5-1X/193LA15UMC

R900944135 PVV41-1X/122-018RA15DDMC

R900943716 PVV5-1X/154RA15UMC

R900943199 PVV2-1X/055RB15DMB

R900943054 PVV4-1X/113RA15UVC

R900942737 PVV4-1X/082LA15DMC

R900942489 PVV5-1X/193RB15UMC

R900942298 PVV2-1X/045RJ15UMB

R900942277 PVV52-1X/193-060RA15UUMC

R900942115 PVV2-1X/040RA15DMB

R900942114 PVV1-1X/018RA15DMB

R900942110 PVV5-1X/183RA15UMC

R900942109 PVV52-1X/139-068RA15UUMC

R900942108 PVV4-1X/098RJ15UMC

R900941961 PVV54-1X/139-082RA15UUMC

R900941702 PVV1-1X/046RJ15UMB

R900941701 PVV51-1X/183-040RA15UUMC

R900941700 PVV51-1X/193-046RA15UUMC

R900941699 PVV4-1X/098RA15RMC

R900941698 PVV2-1X/055RA15RMB

R900941697 PVV42-1X/113-068RB15URMC

R900941692 PVV4-1X/122RJ15DMC

R900941691 PVV2-1X/068RJ15DMB

R900941684 PVV1-1X/040RJ15DMB

R900941572 PVV2-1X/060RA15UMB

R900940633 PVV1-1X/018RA15UMB

R900940588 PVV21-1X/040-027RA15DDMB

R900940587 PVV21-1X/040-018RA15DDMB

R900940446 PVV2-1X/055RJ15UMB

R900940260 PVV1-1X/027RJ15UMB

R900940215 PVV2-1X/060RB15DMB

R900939702 PVV52-1X/193-055RA15UUMC

R900939526 PVV1-1X/036RJ15UMB

R900939497 PVV54-1X/139-098RB15UUMC

R900939347 PVV2-1X/055LA15DMB

R900939078 PVV5-1X/193RJ15DMC

R900939075 PVV1-1X/027RJ15DMB

R900939042 PVV5-1X/193RA15RMC

R900939041 PVV5-1X/183RA15RMC

R900939040 PVV2-1X/068RA15RMB

R900938819 PVV4-1X/113RA15UMC

R900937555 PVV41-1X/082-040RA15DDMC

R900937335 PVV52-1X/193-068RA15UUMC

R900937333 PVV42-1X/082-045RA15UUMC

R900937332 PVV21-1X/040-018RA15UUMB

R900937330 PVV4-1X/082RA15LMC

R900936954 PVV1-1X/027RA15UMB

R900936923 PVV5-1X/162RA15UMC

R900936760 PVV1-1X/036RA15UMB

R900936492 PVV5-1X/162RA15DMC

R900936491 PVV4-1X/113RA15DMC

R900936297 PVV5-1X/183RA15DMC

R900936296 PVV5-1X/154RA15DMC

R900936294 PVV4-1X/098RA15DMC

R900936293 PVV4-1X/069RA15DMC

R900936292 PVV2-1X/045RA15DMB

R900936290 PVV2-1X/055RA15DMB

R900936197 PVV2-1X/060RA15DMB

R900936150 PVV54-1X/183-122RA15UUMC

R900935891 PVV1-1X/036RA15DMB

R900935879 PVV41-1X/122-027RA15UUMC

R900935466 PVV2-1X/068RA15DMB

R900935445 PVV4-1X/069RA15UMC

R900934793 PVV5-1X/162RB15UMC

R900934061 PVV42-1X/098-045RA15DDMC

R900934058 PVV21-1X/060-040RA15DDMB

R900933057 PVV4-1X/082RA15RMC

R900932732 PVV5-1X/139RA15DMC

R900931901 PVV21-1X/055-018RA15UUMB

R900931548 PVV4-1X/082RA15DMC

R900931256 PVV2-1X/068RA15UVB

R900931138 PVV2-1X/040RA15UMB

R900931136 PVV4-1X/082RA15UMC

R900930907 PVV4-1X/098RA15UMC

R900965263 PVV42-1X/122-040RA15UUMC

R900954326 PVV5-1X/139RA15UMC

R900942115 PVV2-1X/040RA15DMB

R900941699 PVV4-1X/098RA15RMC

R900941691 PVV2-1X/068RJ15DMB

R900941572 PVV2-1X/060RA15UMB

R900940633 PVV1-1X/018RA15UMB

R900939702 PVV52-1X/193-055RA15UUMC

R900936954 PVV1-1X/027RA15UMB

R900936760 PVV1-1X/036RA15UMB

R900936491 PVV4-1X/113RA15DMC

R900936297 PVV5-1X/183RA15DMC

R900936294 PVV4-1X/098RA15DMC

R900936292 PVV2-1X/045RA15DMB

R900935891 PVV1-1X/036RA15DMB

R900935466 PVV2-1X/068RA15DMB

R900932732 PVV5-1X/139RA15DMC

R900931548 PVV4-1X/082RA15DMC

R900930907 PVV4-1X/098RA15UMC

R900929542 PVV4-1X/122RA15DMC